2001 Toyota Tacoma

Family: Tacoma · filed with NHTSA as PRERUNNER, TACOMA

Summary

Of the 378 complaints that name a component, 61% concern Body & Structure (232).
These are complaint counts, not failure rates: they are not divided by how many cars were sold, because no public source reports U.S. sales by model year.
Not enough history to compare this year with the rest of its generation.
6 recalls filed for this model year.
No federal defect investigations cover this model year.

At a glance

Owner complaints: 403
Recalls: 6
Investigations: 0
NCAP overall: Not rated
Combined MPG: 16–21
Annual fuel cost: $2,950–$3,900
Median mileage at complaint: 144,000 mi (n = 301)
Crashes / fires / injuries / deaths: 41 / 4 / 37 / 4

What owners report

Body & Structure

232 complaints · 61% of complaints that name a component · median 144,233 mi (n = 192)

Owner report We purchased a 2001 Toyota Tacoma Prerunner from a used car lot in Omaha NE. We have had it for 3 months and recently had a mechanic look over the vehicle for repairs. The mechanic indicated the frame is rusted through and the truck is unsafe to drive. The mechanic indicated that there was a recall on the frames possib…

Owner report The contact owns a 2001 Toyota Tacoma. The contact stated that the vehicle was previously serviced under recall for corrosion underneath the vehicle. The contact became aware that there was corrosion underneath the vehicle. The vehicle was taken back to the dealer and rust protection was sprayed on the corrosion but th…

Suspension

84 complaints · 22% of complaints that name a component · median 170,000 mi (n = 60)

Owner report The contact owns a 2001 Toyota Tacoma. The contact stated while driving approximately 60 MPH, the contact swerved to the left to avoid another vehicle and the steering had stiff. The contact stated that the front driver’s side wheel then collapsed inside the wheel well. The contact lost control of the vehicle and the v…

Owner report MY FRAME IS COMPLETELY RUSTED AND ALL THE CAPOMINTES ARE ALSO. I CANT CHANGE ANYTHING PUT BECAUSE OF IT. MY LEAF SPRINGS ARE SHOT WHERE THEY ARE MOUNTED TO THE FRAME. IS WEAKING WHICH IS MOVING MY BACK AXLE OFF BALANCE. MY FRONT AILMENT IS COMPLETELY OFF. I AND DREAK ANYTHING LOSE TO FIX THE ISSUE'S. IT FEELS LIKE THEY…

Brakes

22 complaints · 6% of complaints that name a component · median 143,000 mi (n = 14)

Owner report OUR 2001 TOYOTA TACOMA 4WD DOUBLE CAB (WITH 143,000 MILES AND EXCELLENT CONDITION) ABS CONTROL UNIT FAILED SOMETIMES IN EARLY JAN 2020. AFTER WE SEARCHED FOR REPLACEMENT PART ON TOYOTA DEALERS' WEBSITES, THEY SHOWED "THIS PRODUCT IS NO LONGER AVAILABLE." OUR SHOP SEARCHED AND WAS TOLD BY TOYOTA DEALERS THE SAME THING. …

Owner report THE BRAKES FAILED DUE TO LOSS OF HYDRAULIC FLUID. THIS OCCURRED SUDDENLY. THE STEEL HYDRAULIC BRAKE LINE HAS CORRODED AND RUPTURED WITHIN AN INCH OF WHERE IT CONNECTS TO THE BRAKE BIAS VALVE NEAR THE LEFT REAR WHEEL. UPON INSPECTION OF THE AREA AROUND THE BRAKE BIAS VALVE, THE BIAS VALVE ITSELF, THE BOLTS SECURING T…

6% of complaints name no specific component and are left out of the shares above.

Across the generation (1996–2004)

To compare years fairly, each year is counted over the same span: complaints received up to two calendar years after its model year. A year is compared only when that span is over and it holds at least 50 complaints. Median of the comparable years: 66.

Model year	All complaints	First three years	Note
1996	253	70
1997	134	30	not compared
1998	302	112	most complaints
1999	256	75
2000	211	63
2001	403	30	not compared
2002	339	52
2003	360	43	not compared
2004	415	51

Recalls

Whether a recall has been fixed on a specific car depends on its VIN; check it at nhtsa.gov/recalls.

12V542000 · TIRES:TEMPORARY/EMERGENCY SPARE TIRE

Filed 2012-11-23 · 150,000 vehicles

Defect: Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.

Risk: Corrosion of the plate could cause it to break, which could result in detachment of the spare tire from the vehicle. Detachment of the spare tire could result in a road hazard which may increase the risk of a vehicle crash.

Remedy: Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

06E065000 · EXTERIOR LIGHTING

Filed 2006-07-17 · 3,593 vehicles

Defect: CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

06E026000 · EXTERIOR LIGHTING

Filed 2006-03-23 · 61,944 vehicles

Defect: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

05V225000 · SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Filed 2005-05-17 · 768,379 vehicles

Defect: ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.

Risk: THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.

Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

03V189000 · FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Filed 2003-05-19 · 123,360 vehicles

Defect: ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.

Risk: THIS DAMAGE COULD RESULT IN FUEL LEAKAGE, WHICH COULD RESULT IN A FIRE IF IN THE PRESENCE OF AN IGNITION SOURCE.

Remedy: DEALERS WILL INSTALL A FUEL HOSE PROTECTOR ON THE BODY FLANGE. OWNER NOTIFICATION BEGAN JUNE 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

01V186000 · TIRES:SIDEWALL

Filed 2001-06-07 · 43 vehicles

Defect: VEHICLE DESCRIPTION: 4X2 TRUCKS EQUIPPED WITH TU4 WHITE LETTER TIRE UPGRADE OPTION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. TIRE DAMAGE MAY HAVE OCCURRED DUE TO IMPROPER INSTALLATION, WHICH COULD CAUSE THE TIRE TO DEFLATE OR A BULGE APPEARING IN THE SIDEWALL OF THE TIRE.

Risk: AN IMPROPERLY INFLATED TIRE COULD RESULT IN VEHICLE HANDLING PROBLEMS OR A BLOW OUT OF AN IMPROPERLY INSTALLED TIRE.

Remedy: DEALERS WILL CHECK ALL FOUR TIRES, REBALANCE AND, IF NECESSARY, REPLACE ANY DAMAGED TIRE. OWNER NOTIFICATION BEGAN JULY 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Federal investigations

None on file.

Engines and fuel economy

Version	Engine	Transmission	Drive	City	Hwy	Combined	Fuel cost / yr
Tacoma 2WD	2.4L 4cyl	Automatic 4-spd	Rear-Wheel Drive	19	22	20	$3100
Tacoma 2WD	2.4L 4cyl	Manual 5-spd	Rear-Wheel Drive	19	23	21	$2950
Tacoma 2WD	2.7L 4cyl	Automatic 4-spd	Rear-Wheel Drive	17	20	18	$3450
Tacoma 2WD	3.4L 6cyl	Automatic 4-spd	Rear-Wheel Drive	15	18	17	$3650
Tacoma 2WD	3.4L 6cyl	Manual 5-spd	Rear-Wheel Drive	16	20	18	$3450
Tacoma 4WD	2.7L 4cyl	Automatic 4-spd	4-Wheel or All-Wheel Drive	17	19	18	$3450
Tacoma 4WD	2.7L 4cyl	Manual 5-spd	4-Wheel or All-Wheel Drive	17	20	18	$3450
Tacoma 4WD	3.4L 6cyl	Automatic 4-spd	4-Wheel or All-Wheel Drive	15	18	16	$3900
Tacoma 4WD	3.4L 6cyl	Manual 5-spd	4-Wheel or All-Wheel Drive	15	18	17	$3650

Fuel cost is EPA's estimate at the fuel prices of its last update, not today's.

Crash test ratings (NCAP)

Variant	Overall	Frontal	Side	Rollover
2001 Toyota Tacoma 4-DR.	Not Rated	Not Rated	Not Rated	★★☆☆☆
2001 Toyota Tacoma Extended Cab	Not Rated	Not Rated	Not Rated	Not Rated

Service bulletins

Toyota issued 138 service bulletins listed against this model year, most often about equipment.

A bulletin tells dealers how to fix a known condition. It is not a recall and not a defect finding. Most bulletins cover several model years at once, so one listed here may not be specific to this year. The number of bulletins tracks how long and how widely a model was sold, so it is not a measure of reliability.

Date	Component	Summary
2024-12-06	STRUCTURE:BODY	Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood…
2024-12-06	STRUCTURE:BODY	To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and in…
2024-12-06	STRUCTURE:BODY	The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicl…
2024-12-05	STRUCTURE:BODY	Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. Follow the Removal Procedure …
2024-12-03	STRUCTURE:BODY	Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. This type of contamination can be identified by the …
2024-07-12	STRUCTURE:BODY	Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood…
2024-07-12	STRUCTURE:BODY	To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and in…
2024-07-12	STRUCTURE:BODY	The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicl…
2024-07-12	STRUCTURE:BODY	Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood…
2024-07-12	STRUCTURE:BODY	To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and in…

How to read this page

Complaint counts are not failure rates. A model that sells more cars draws more complaints, and owners file more often after news coverage or a recall. That is why this page compares a model year only with other years of the same generation, never with other models.

Each complaint is counted once, even when it names several components; a complaint that names several systems appears under each of them. Owner reports are quoted as filed and have not been verified by NHTSA or by us.

Every model year of this Tacoma, including the ones without a page of their own, is listed on the Toyota Tacoma model page.

Sources

NHTSA Office of Defects Investigation: complaints, recalls and investigations (bulk files, data as of 2026-10-28).
NHTSA New Car Assessment Program: crash test ratings.
U.S. EPA / DOE fueleconomy.gov: engines, transmissions and fuel economy.

MotorAlmanac is independent and not affiliated with NHTSA, EPA or any manufacturer. This page summarises public records; it is not a mechanical inspection. Before buying a used car, check its VIN for open recalls and have it inspected.