Family: Windstar · filed with NHTSA as WINDSTAR
Owner report WHEN TRAVELING 15 MPH ON BRICK ROAD I PRESSED BRAKES TO STOP THEN LOUD NOISE AND CAR STILL ROLLED FORWARD - SCARY AND UNSAFE. THIS HAS HAPPENED TWICE UNDER DIFFERENT CONDITIONS - THE ABS LIGHT IS ON IN MY VEHICLE
Owner report THE PARK AND BRAKE LIGHT KEEPS COMING ON, LOOKED UP AND IT SAID THE ABS SYSTEM IS NOT WORKING LIKE IT SHOULD. THIS HAPPENS WHEN I'M DRIVING IN CITY , HIGHWAYS, NOT MOVING.
Owner report WHILE HIGHWAY DRIVING, THE SPEEDOMETER, GAS GAUGE, TEMPERATURE GAUGE AND INSTRUMENT LIGHTING BECAME ERRATIC AND FAILED. A SHORT TIME LATER THE SITUATION NORMALIZED. SEVERAL MONTHS PRIOR THE TACHOMETER MALFUNCTIONED AND BECAME INOPERABLE.
Owner report WHILE DRIVING AT NIGHT ON THE INTERSTATE OR ANY OTHER ROAD, THE HEADLIGHTS SUDDENLY WENT OFF FOR ABOUT 10 SECONDS. I HEARD A CLICKING SOUND UNDER THE LEFT SIDE OF THE DASH LIKE THE SOUND OF A RELAY ENGAGING. THIS HAPPENED SEVERAL TIMES. I HAD THE BATTERY REPLACED AND IT WAS OK FOR ABOUT 2-3 WEEKS THEN STARTED AGAIN. DR…
Owner report The contact owns a 2003 Ford Windstar. The contact stated that while driving over a railroad track at 40 MPH, the rear axle snapped. The wheel hub to the axle was barely connected. The contact referenced NHTSA Campaign Number:15V608000 (SUSPENSION); however, the contact had not received the recall notification. The dea…
Owner report The contact owns a 2003 Ford Windstar. The contact stated while attempting to reverse, the contact heard a loud sound coming from the front of the vehicle. The contact stated that steering wheel became difficult to turn. A local dealer was contacted. The vehicle was taken to the dealer where it was inspected, and the c…
1% of complaints name no specific component and are left out of the shares above.
To compare years fairly, each year is counted over the same span: complaints received up to two calendar years after its model year. A year is compared only when that span is over and it holds at least 50 complaints. Median of the comparable years: 132.
| Model year | All complaints | First three years | Note |
|---|---|---|---|
| 1999 | 1,522 | 312 | most complaints |
| 2000 | 1,675 | 261 | most complaints |
| 2001 | 1,686 | 132 | |
| 2002 | 1,353 | 75 | fewest complaints |
| 2003 | 1,510 | 95 |
Whether a recall has been fixed on a specific car depends on its VIN; check it at nhtsa.gov/recalls.
Defect: Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195.
Risk: If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. If a bracket is found to have been misinstalled, the rear axle will be replaced. These repairs will be performed free of charge. The began on October 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S27.
Defect: FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATE OF VIRGINIA. CORROSION-RELATED FRACTURES OF THE FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BODY MOUNT ATTACHMENTS MAY OCCUR.
Risk: A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT. EITHER CONDITION COULD RESULT IN SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Defect: FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK.
Risk: A FRACTURED AXLE MAY RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL A REINFORCEMENT BRACKET ON THE REAR AXLE OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Defect: FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN VIRGINIA. OVER TIME, CORROSION CAN WEAKEN THE REAR AXLE MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH, IF UNDETECTED, CAN INCREASE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Risk: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL REAR AXLE REINFORCEMENT BRACKETS, OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Defect: FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, UTAH, VERMONT, WEST VIRGINIA, AND WISCONSIN. A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT.
Risk: THIS COULD RESULT IN REDUCED STEERING CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS, AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME, AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. IF REPAIRS CANNOT BE MADE TO A VEHICLE, FORD WILL OFFER TO REPURCHASE THE VEHICLE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 21, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Defect: FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Risk: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.
Remedy: AS PARTS BECOME AVAILABLE, DEALERS WILL INSPECT AND IF NECESSARY INSTALL THE REAR AXLE REINFORCEMENT BRACKETS FREE OF CHARGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Defect: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Defect: CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Risk: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Defect: CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." DURING TESTING, A THIRD ROW BENCH FLOOR-TO-SEAT LATCH RELEASED BEFORE THE STRENGTH REQUIREMENT WAS MET. IDENTICAL LATCHES ARE USED IN THE SECOND ROW OF SEATS.
Risk: IF THE LATCHES ON TH4E SECOND OR THIRD ROW SEATS OF THE VEHICLE RELEASE IN A CRASH, THE POTENTIAL FOR OCCUPANT INJURY IS INCREASED.
Remedy: DEALERS WILL REPLACE THE SEAT-TO-FLOOR LATCHES ON THE SECOND AND THIRD ROW OF SEATS. OWNER NOTIFICATION BEGAN ON NOVEMBER 21, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
| Action | Component | Opened | Closed | Recall |
|---|---|---|---|---|
| EA10007 | STRUCTURE:FRAME AND MEMBERS | 2010-12-20 | 2011-03-17 | 11V030000 |
| DP10005 | SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY | 2010-12-15 | 2010-12-21 | |
| PE10026 | STRUCTURE:FRAME AND MEMBERS | 2010-07-20 | 2010-12-20 | 11V030000 |
| PE10016 | SUSPENSION | 2010-05-13 | 2010-09-22 | 10V385000 |
| EA08021 | ELECTRICAL SYSTEM | 2008-09-17 | 2009-10-14 | 09V399000 |
| PE08035 | ELECTRICAL SYSTEM | 2008-05-13 | 2008-09-17 |
EA10007: Front Subframe Corrosion Failures
DP10005: Rear Axle Fracture Recall Scope
PE10026: Front Subframe Corrosion Failures
PE10016: Rear Axle Cracking
EA08021: ENGINE COMPARTMENT FIRES
PE08035: ENGINE COMPARTMENT FIRES
| Version | Engine | Transmission | Drive | City | Hwy | Combined | Fuel cost / yr |
|---|---|---|---|---|---|---|---|
| Windstar FWD Cargo Van | 3.8L 6cyl | Automatic 4-spd | Front-Wheel Drive | 16 | 22 | 18 | $3450 |
| Windstar FWD Wagon | 3.8L 6cyl | Automatic 4-spd | Front-Wheel Drive | 16 | 22 | 18 | $3450 |
Fuel cost is EPA's estimate at the fuel prices of its last update, not today's.
| Variant | Overall | Frontal | Side | Rollover |
|---|---|---|---|---|
| 2003 Ford Windstar | Not Rated | Not Rated | Not Rated | Not Rated |
| 2003 Ford Windstar w/SAB | Not Rated | Not Rated | Not Rated | Not Rated |
Ford issued 68 service bulletins listed against this model year, most often about electrical system.
A bulletin tells dealers how to fix a known condition. It is not a recall and not a defect finding. Most bulletins cover several model years at once, so one listed here may not be specific to this year. The number of bulletins tracks how long and how widely a model was sold, so it is not a measure of reliability.
| Date | Component | Summary |
|---|---|---|
| 2020-04-20 | STRUCTURE | For 1999-2003 Windstar vehicles Safety Recall 11S16 has been issued for vehicles that are operated in high corrosion areas for an extended period, where a front subframe lower control arm (LCA) rear attaching flange or rear body mount could… |
| 2016-04-21 | SUSPENSION | For 1998-2003 Windstar vehicles Safety Recall 10S13 has been issued for vehicles that are operated in high corrosion areas for an extended period, where the rear axle could potentially fracture. If the rear axle should completely fracture, … |
| 2016-04-21 | SUSPENSION:MULTIPLE AXLE | Safety recall 10S13 - Rear axle corrosion - requests for recall service action |
| 2016-04-20 | STRUCTURE | Safety recall 11s16 - LCA rear attaching flanges or rear subframe body mount corrosion - requests for recall service action |
| 2015-09-29 | SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY | SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| 2014-09-09 | SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY | FORD: SAFETY RECALL CONCERNING REAR AXLE FRACTURING IF VEHICLE IS OPERATED IN HIGH CORROSION AREAS FOR AND EXTENDED PERIOD. MODEL 1998-03 WINDSTAR. *PE |
| 2014-09-09 | STRUCTURE:FRAME AND MEMBERS | FORD: SAFETY RECALL ON FRONT SUBFRAME LOWER CONTROL ARM (LCA) REAR ATTACHING FLANGE OR REAR BODY MOUNT THAT CAN SEPARATE FROM SUBFRAME IF VEHICLE IS OPERATED, FOR EXTENDED PERIOD, IN HIGH CORROSION AREAS. MODEL 1999-03 WINDSTAR. |
| 2014-08-11 | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM | FORD: A SAFETY RECALL HAS BEEN ISSUED ON MINIVANS WHERE LOWER CONTROL ARM (LCA) OF FRONT SUBFRAME ATTACHING REAR FLANGE OR REAR BODY MOUNT CAN SEPARATE DUE TO CORROSION. MODEL 1999-2003 WINDSTAR. *PE |
| 2014-08-11 | SUSPENSION:REAR:AXLE:SPINDLE | FORD: ON SOME MINIVANS, REAR AXLE WILL FRACTURE, IN HIGH CORROSION AREA, AFTER OPERATING FOR AN EXTENDED TIME PERIOD, AND VEHICLE HANDLING ABILITY WILL BE AFFECTED. MODEL 1998-2003 WINDSTAR. *PE |
| 2005-06-07 | SEAT BELTS:FRONT:RETRACTOR | SAFETY BELT RETRACTION SPEED. *TT |
Complaint counts are not failure rates. A model that sells more cars draws more complaints, and owners file more often after news coverage or a recall. That is why this page compares a model year only with other years of the same generation, never with other models.
Each complaint is counted once, even when it names several components; a complaint that names several systems appears under each of them. Owner reports are quoted as filed and have not been verified by NHTSA or by us.
Every model year of this Windstar, including the ones without a page of their own, is listed on the Ford Windstar model page.
MotorAlmanac is independent and not affiliated with NHTSA, EPA or any manufacturer. This page summarises public records; it is not a mechanical inspection. Before buying a used car, check its VIN for open recalls and have it inspected.