Toyota / FJ Cruiser / 2007
Family: FJ Cruiser · filed with NHTSA as FJ CRUISER
Owner report Took FJ in for an inspection and was informed the frame was rusted to the point it could not pass inspection.
Owner report The contact owns a 2007 Toyota FJ Cruiser. The contact stated that while her son was attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to an independent mechanic; however, no cause for the failure was found. The independent mechanic informed the contact that the undercarriage and subfr…
Owner report WIDOW WIPERS MOTOR FAILURE THE MOTOR OR THE ASSEMBLY AND ITS BUSHINGS DON'T HAVE PROPER SEALS WHICH ALLOWS WATER INTO DESTROY THE BUSHINGS BY NOT BEINGVABLE TO RETAIN GREASE TO PREVENT PITTING AND RUST WHICH RESULTS IN WINDOW WIPER FAILURE AND A 600DOLLAR COST OF REPLACEMENT OF MOTOR AND ARMATURE ASSEMBLY WHICH IS JUS…
Owner report DUE TO THE STEEP VERTICAL ANGLE OF THE WINDSHIELD AND THE PLACEMENT OF THE DEFROSTER VENT SEVERAL INCHES BACK FROM THE WINDSHIELD, THE WINDSHIELD CANNOT BE KEPT CLEAR BY THE DEFROSTER. THE AIRSTREAM FROM THE DEFROSTER DOES NOT HIT THE LOWER 1/3 OF THE WINDSHIELD AND THE LEFT HAND DRIVER SIDE AND NO AMOUNT OF AIR EVEN A…
Owner report Our 2007 FJ Cruiser when brought in for annual inspection has been deemed unsafe for use due to crack in frame due to corrosion. The vehicle has no other mechanical issues and runs as if new. We invested in 5 new tires and now find ourselves possibly having to purchase a new vehicle. We witnessed all the other Toyota …
Owner report My recently purchased Toyota FJ Cruiser was found to have severe rust underneath the car . Nuts and bolts have rotted away with the part now held together by rust weld. New straps are holding up a dented gas tank which my mechanic thinks fell when the original straps failed. Is it a safety issue when a gas tank falls o…
6% of complaints name no specific component and are left out of the shares above.
To compare years fairly, each year is counted over the same span: complaints received up to two calendar years after its model year. A year is compared only when that span is over and it holds at least 50 complaints.
| Model year | All complaints | First three years | Note |
|---|---|---|---|
| 2007 | 593 | 173 | |
| 2008 | 124 | 45 | not compared |
| 2009 | 7 | 2 | not compared |
| 2010 | 66 | 30 | not compared |
| 2011 | 23 | 12 | not compared |
| 2012 | 41 | 15 | not compared |
| 2013 | 23 | 6 | not compared |
| 2014 | 30 | 9 | not compared |
Whether a recall has been fixed on a specific car depends on its VIN; check it at nhtsa.gov/recalls.
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Defect: Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."
Risk: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.
Defect: Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.
Risk: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.
Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.
Defect: Toyota is recalling certain Toyota Racing Development (TRD) brake kits, P/N PTR09-35070, and TRD High-Performance brake kits, P/N PTR09-35100, installed by Toyota vehicle processing centers and sold by Toyota dealers as an optional accessory for model year 2007 through 2012 Toyota FJ Cruiser vehicles. The subject TRD brake kit is specifically designed for the front wheels of 2007-2012 model year FJ Cruiser vehicles. Due to the shape of the outer brake tube of the brake kit, the clearance between the outer brake tube and a TRD 16 inch 6-spoke alloy wheel is minimal. If wheel balance weights are installed in an incorrect location, there is a possibility that the outer brake tube could be damaged due to interference with the balance weight, and brake fluid could leak from the damaged tube.
Risk: If a brake tube becomes damaged and leaks fluid, it may result in increased stopping distances, and in some cases, loss of vehicle front braking performance, which could increase the risk of a crash.
Remedy: All known owners of 2007-2012 model year FJ Cruiser vehicles will be notified by first class mail. If the vehicle is equipped with one of the TRD brake kits, the brake caliper outer brake tube will be replaced with a newly designed one at no charge. During this service, if necessary, the dealer will make wheel balance adjustments. This remedy will be performed even if the vehicle has original equipment 16 inch or 17 inch wheels or TRD 16 inch Beadlock ring type wheels, which are not affected by the condition, to assure sufficient clearance in the event wheels are changed at a later time. Notification to owners began on December 17, 2012. Owners may contact Toyota Customer Experience Center at 1-800-331-4331.
Defect: GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Defect: SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Defect: TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Risk: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Defect: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH EITHER BRIDGESTONE DUELER OR DUNLOP GRANDTREK TIRES, THERE IS A POSSIBILITY THAT THE INNER BEAD OF THE TIRE MAY HAVE BEEN DAMAGED. IF THE BEAD IS DAMAGED, A BULGE MAY DEVELOP ON THE SIDEWALL OF THE TIRE AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD.
Risk: IF THE TIRE LOSES AIR PRESSURE IT MAY LEAD TO A LOSS OF VEHICLE CONTROL AND INCREASE THE POSSIBILITY OF A CRASH.
Remedy: DEALERS WILL INSPECT ALL FIVE TIRES, INCLUDING THE SPARE TIRE, TO DETERMINE IF THEY ARE WITHIN THE AFFECTED TIRE-TO-WHEEL ASSEMBLY RANGE AND REPLACE ALL INVOLVED TIRES WITH NEW TIRES FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. NOTE: DUE TO AN ERROR IN THE DOT SERIAL NUMBER SECTION OF THE TECHNICAL INSTRUCTIONS, A NUMBER OF VEHICLES WERE NOT INSPECTED CORRECTLY. TOYOTA RELAUNCHED THIS CAMPAIGN IN MID-AUGUST 2006.
None on file.
| Version | Engine | Transmission | Drive | City | Hwy | Combined | Fuel cost / yr |
|---|---|---|---|---|---|---|---|
| FJ Cruiser 2WD | 4.0L 6cyl | Automatic 5-spd | Rear-Wheel Drive | 17 | 21 | 18 | $4300 |
| FJ Cruiser 4WD | 4.0L 6cyl | Automatic 5-spd | 4-Wheel or All-Wheel Drive | 15 | 19 | 17 | $4550 |
| FJ Cruiser 4WD | 4.0L 6cyl | Manual 6-spd | 4-Wheel or All-Wheel Drive | 15 | 18 | 16 | $4850 |
Fuel cost is EPA's estimate at the fuel prices of its last update, not today's.
| Variant | Overall | Frontal | Side | Rollover |
|---|---|---|---|---|
| 2007 Toyota FJ Cruiser 4-DR. | Not Rated | Not Rated | Not Rated | ★★★☆☆ |
Toyota issued 163 service bulletins listed against this model year, most often about equipment.
A bulletin tells dealers how to fix a known condition. It is not a recall and not a defect finding. Most bulletins cover several model years at once, so one listed here may not be specific to this year. The number of bulletins tracks how long and how widely a model was sold, so it is not a measure of reliability.
| Date | Component | Summary |
|---|---|---|
| 2026-01-07 | UNKNOWN OR OTHER | Some 2005 – 2026 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Serv… |
| 2024-12-06 | STRUCTURE:BODY | Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood… |
| 2024-12-06 | STRUCTURE:BODY | To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and in… |
| 2024-12-06 | STRUCTURE:BODY | The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicl… |
| 2024-12-05 | STRUCTURE:BODY | Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. Follow the Removal Procedure … |
| 2024-12-03 | STRUCTURE:BODY | Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. This type of contamination can be identified by the … |
| 2024-07-29 | STRUCTURE:BODY | Some 2005 – 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Serv… |
| 2024-07-29 | STRUCTURE:BODY | Some 2005 – 2024 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Serv… |
| 2024-07-12 | STRUCTURE:BODY | Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood… |
| 2024-07-12 | STRUCTURE:BODY | To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and in… |
Complaint counts are not failure rates. A model that sells more cars draws more complaints, and owners file more often after news coverage or a recall. That is why this page compares a model year only with other years of the same generation, never with other models.
Each complaint is counted once, even when it names several components; a complaint that names several systems appears under each of them. Owner reports are quoted as filed and have not been verified by NHTSA or by us.
Every model year of this FJ Cruiser, including the ones without a page of their own, is listed on the Toyota FJ Cruiser model page.
MotorAlmanac is independent and not affiliated with NHTSA, EPA or any manufacturer. This page summarises public records; it is not a mechanical inspection. Before buying a used car, check its VIN for open recalls and have it inspected.