2005 Toyota Highlander

Family: Highlander · filed with NHTSA as HIGHLANDER, HIGHLANDER HYBRID

Summary

In its first three years the 2005 Highlander drew 53 complaints — 1.0× the median of its generation (2001–2007). It does not stand out from the other years of this generation.
These are complaint counts, not failure rates: they are not divided by how many cars were sold, because no public source reports U.S. sales by model year.
Complaints are spread across systems: the largest, Powertrain, holds 23% of the 221 that name a component.
6 recalls filed for this model year.
1 federal defect investigation covers this model year.

At a glance

Owner complaints: 225
Recalls: 6
Investigations: 1
NCAP overall: Not rated
Combined MPG: 19–22
Annual fuel cost: $2,850–$3,300
Median mileage at complaint: 56,500 mi (n = 172)
Crashes / fires / injuries / deaths: 35 / 4 / 20 / 0

What owners report

Powertrain

51 complaints · 23% of complaints that name a component · median 50,000 mi (n = 38)

Owner report TRANSAXLE VENT IS LEAKING TRANSMISSION FLUID ONTO EXHAUST, POTENTIAL OF CATASTRAPHIC TRANSMISSION FAILURE DUE TO TOTAL SUDDEN LOSS OF TRANSMISSION FLIUD. LEAK IS CAUSE BY A DEFECTIVE SEAL

Owner report MY HIGHLANDER HAS 120,000 MILES ON IT AND THE TRANSMISSION SUDDENLY GAVE OUT WHILE DRIVING ON THE HIGHWAY. IT STARTED BY DOWNSHIFTING SUDDENLY, MAKING IT DIFFICULT TO RETAIN CONTROL OF THE VEHICLE. THEN I LOST ALL FORWARD POWER AND HAD TO COAST TO A STOP ON THE SIDE OF THE INTERSTATE. I AM NOW STUCK PAYING A $3500+ REP…

Accelerator & Cruise Control

39 complaints · 18% of complaints that name a component · median 44,200 mi (n = 29)

Owner report BACKING UP OUT OF DRIVEWAY PUT THE CAR INTO REVERSE WENT FROM BRAKE PEDAL TO GAS PEDAL TAPING THE GAS PEDAL LIGHTLY TO INCH OUT OF DRIVEWAY SLOWLY. AFTER ONE TAP ON THE GAS PEDAL THE CAR ACCELERATED AT A VERY HIGH RATE OF SPEED CAUSING DRIVER TO LOOSE CONTROL. VEHICLE CRASHED INTO CHAIN LINK FENCE WHICH IN TURN CRASHE…

Owner report MY CAR WAS DECELERATING IN THE FAR RIGHT TURN LANE OF A BUSY INTERSECTION. THE BRAKE HAD BEEN APPLIED APPROXIMATELY 1000 FT FROM THE INTERSECTION AS THERE WERE 3 VEHICLES STOPPED AHEAD OF ME. I WAS TRAVELING AT 10 MPH AND I INCREASED THE PRESSURE TO THE BRAKE PEDAL AS THE CAR APPROACHED A STOPPED VEHICLE APPROXIMATELY …

Windows, Wipers & Visibility

28 complaints · 13% of complaints that name a component · median 80,000 mi (n = 22)

Owner report THE DRIVER SIDE VISOR IS DROOPING MORE AND MORE. NOW IT IS PARTLY IN MY LINE OF SIGHT (I'M 6'3") AND WHEN I HIT A BUMP IT DROPS DOWN EVEN FURTHER AND BLOCKS ABOUT HALF OF MY VISION OUT THE WINDSHIELD. VERY DANGEROUS. BEFORE I START DRIVING, I CAN GENTLY RAISE IT AND SLOWLY LET IT DROP TO WHERE IT STOPS WHERE IT ONLY P…

Owner report HEWLLO MY COMPLAINT IS ABOUT THE DRIVERS SIDE SUN VISOR.IT WONT STAY UP AND HASNT FOR ABOUT A YEAR. I HAVE READ THAT A LOT OF HIGHLANDER OWNERS ARE HAVING THIS PROBLEM AND IT MAKES IT VERY HARD TO SEE.A NEW COSTS ABOUT 175.00!

2% of complaints name no specific component and are left out of the shares above.

Across the generation (2001–2007)

To compare years fairly, each year is counted over the same span: complaints received up to two calendar years after its model year. A year is compared only when that span is over and it holds at least 50 complaints. Median of the comparable years: 55.

Model year	All complaints	First three years	Note
2001	137	48	not compared
2002	301	46	not compared
2003	258	47	not compared
2004	286	94	most complaints
2005	225	53
2006	648	55
2007	234	29	not compared

Recalls

Whether a recall has been fixed on a specific car depends on its VIN; check it at nhtsa.gov/recalls.

16V396000 · SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Filed 2016-06-02 · 7,749 vehicles

Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

11V539000 · ENGINE AND ENGINE COOLING

Filed 2011-11-09 · 420,326 vehicles

Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Risk: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Filed 2011-02-24 · 769,379 vehicles

Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Risk: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Filed 2010-10-21 · 728,544 vehicles

Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Risk: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

10V035000 · EQUIPMENT:OTHER:LABELS

Filed 2010-02-03 · 271,417 vehicles

Defect: GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

06V253000 · VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Filed 2006-07-13 · 367,594 vehicles

Defect: ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Risk: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

Federal investigations

Action	Component	Opened	Closed	Recall
RQ10003	ELECTRICAL SYSTEM:SOFTWARE	2010-02-16	2011-03-01	11V112000

RQ10003: Unintended and Uncontrolled Acceleration

Engines and fuel economy

Version	Engine	Transmission	Drive	City	Hwy	Combined	Fuel cost / yr
Highlander 2WD	2.4L 4cyl	Automatic 4-spd	Front-Wheel Drive	19	25	22	$2850
Highlander 2WD	3.3L 6cyl	Automatic 5-spd	Front-Wheel Drive	17	23	19	$3300
Highlander 4WD	2.4L 4cyl	Automatic 4-spd	4-Wheel or All-Wheel Drive	19	23	21	$2950
Highlander 4WD	3.3L 6cyl	Automatic 5-spd	4-Wheel or All-Wheel Drive	16	22	19	$3300

Fuel cost is EPA's estimate at the fuel prices of its last update, not today's.

Crash test ratings (NCAP)

Variant	Overall	Frontal	Side	Rollover
2005 Toyota Highlander 4-DR.	Not Rated	Not Rated	Not Rated	★★★★☆

Service bulletins

Toyota issued 202 service bulletins listed against this model year, most often about equipment.

A bulletin tells dealers how to fix a known condition. It is not a recall and not a defect finding. Most bulletins cover several model years at once, so one listed here may not be specific to this year. The number of bulletins tracks how long and how widely a model was sold, so it is not a measure of reliability.

Date	Component	Summary
2026-01-07	UNKNOWN OR OTHER	Some 2005 – 2026 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Serv…
2024-12-06	STRUCTURE:BODY	Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood…
2024-12-06	STRUCTURE:BODY	To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and in…
2024-12-06	STRUCTURE:BODY	The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicl…
2024-12-06	STRUCTURE:BODY	Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood…
2024-12-06	STRUCTURE:BODY	To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and in…
2024-12-06	STRUCTURE:BODY	The condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. If these contaminants settle and remain on a painted vehicl…
2024-12-05	STRUCTURE:BODY	Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. Follow the Removal Procedure …
2024-12-05	STRUCTURE:BODY	Toyota vehicles are currently protected with RapgardTM protective film designed to protect the horizontal painted surfaces. This material protects from acid rain, environmental fallout, and rail contamination. Follow the Removal Procedure …
2024-12-03	STRUCTURE:BODY	Vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. This type of contamination can be identified by the …

How to read this page

Complaint counts are not failure rates. A model that sells more cars draws more complaints, and owners file more often after news coverage or a recall. That is why this page compares a model year only with other years of the same generation, never with other models.

Each complaint is counted once, even when it names several components; a complaint that names several systems appears under each of them. Owner reports are quoted as filed and have not been verified by NHTSA or by us.

Every model year of this Highlander, including the ones without a page of their own, is listed on the Toyota Highlander model page.

Sources

NHTSA Office of Defects Investigation: complaints, recalls and investigations (bulk files, data as of 2026-10-28).
NHTSA New Car Assessment Program: crash test ratings.
U.S. EPA / DOE fueleconomy.gov: engines, transmissions and fuel economy.

MotorAlmanac is independent and not affiliated with NHTSA, EPA or any manufacturer. This page summarises public records; it is not a mechanical inspection. Before buying a used car, check its VIN for open recalls and have it inspected.